max

Wednesday

2001 Dodge Ram:How to Replace Transmission?

Automatic Transmission Replacement


Basic tools and Auto repair kit is required.

First You will have to disassemble the following things mentioned in correct order:


Remove or disconnect the following:


  • Negative battery cable
  • Rear driveshaft
  • Crankshaft Position (CKP) sensor
  • Exhaust front pipe
  • Transmission braces, if equipped
  • Starter motor
  • Transmission oil cooler lines
  • Torque converter access cover
  • Torque converter
  • Transmission oil dipstick tube
  • Vehicle Speed (VSS) sensor connector
  • Park/Neutral switch connector
  • Shift cable
  • Throttle valve cable
  • Transmission mount and crossmember. Support the transmission.
  • Front driveshaft and transfer case, if equipped
  • Transmission flange bolts
  • Transmission



Now you need replacement transmission and to install:

Follow the list in correct order:

Transmission. Tighten the flange bolts to 65 ft. lbs. (87 Nm).
Front driveshaft and transfer case, if equipped
Transmission mount and crossmember
Throttle valve cable
Shift cable
Park/Neutral switch connector
VSS sensor connector
Transmission oil dipstick tube
Torque converter. Tighten the bolts to 23 ft. lbs. (31 Nm) for 10.75 inch converters and to 35 ft. lbs. (47 Nm) for 12.2 inch converters.
Torque converter access cover
Transmission oil cooler lines
Starter motor
Transmission braces, if equipped. Tighten the bolts to 30 ft. lbs. (41 Nm).
Exhaust front pipe
CKP sensor
Rear driveshaft
Negative battery cable


This details will help.
Thanks.

View The Related Help articles:


HOW TO REPLACE A MANUAL TRANSMISSION
--------------
HOW TO REPLACE TRANSMISSION COOLER LINES
-----------
HOW TO CHECK AUTOMATIC TRANSMISSION FLUID LEVEL
------------
HOW TO CHANGE AUTOMATIC TRANSMISSION FLUID AND FILTER
           
HOW TO REPLACE A TRANSMISSION MOUNT
------------------
DSG automatic transmission problem
--------------
Transmission problem?
---------------
2004 Chrysler 300m: Transmission Relearn Procedure?
----------------
How do you change transmission fluid on Pontiac?
-------------
Filling Transmission fluid on 2001 Volvo c70?
----------------
2002 Isuzu trooper Transmission fluid fill up?
-----------------
AUDI V8 TRANSMISSION FLUID
Where to fill Transmission Fluid on 2001 ford focus
--------------
Coolant enters in transmission on Toyota Land cruiser?
--------------------
Engine stumbles and shuts off in forward gear on Toyota Land Cruiser?
--------------------
Car engine Overheats and transmission starts slipping?
----------------
Manual Transmission Clutch System Failures?
 ---------------------                                      
Automatic transmission will not go into high gear?
------------------                    
Transmission fluid gets into radiator?
---------------
Dodge Anti slip System is not operating?
--------------
How to check Transmission fluid on 1996 Chevrolet Camaro?
-------------    
Transmission fault light on car dash?
-----------------
Filled T-IV fluid instead of WS transmission fluid?
----------
Manual transmission very hard to shift from one gear to another?
-------------------
Bell housing and transmission will not come apart on 1996 Toyota Tacoma?
--------------------
How to Add transmission fluid on 2002 Isuzu AXIOM?
---------------
Chrysler Cirrus Auto Transmission Swap?



No comments:

Post a Comment